adverstisement



CARDINAL INDUSTRIAL FINISHES -- 6402-26280 GRAY, 6402-26280 -- 8010-00N058939
=====================  Product Identification  =====================

Product ID:6402-26280 GRAY, 6402-26280
MSDS Date:09/23/1992
FSC:8010
NIIN:00N058939
MSDS Number: BXHYX
=== Responsible Party ===
Company Name:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTRERO AVE SOUTH
City:EL MONTE
State:CA
ZIP:91733
Country:US
Info Phone Num:818-444-9274
Emergency Phone Num:818-444-9274
Preparer's Name:RICHARD STEWART
CAGE:65860
=== Contractor Identification ===
Company Name:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTERO AVE
Box:City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Phone:818-444-9274 OR 213-283-9335
CAGE:65860

=============  Composition/Information on Ingredients  =============

Ingred Name:ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (CERCLA). VP:
    10.0 @ 68F.
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM; 150 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:2-HEPTANONE; (METHYL AMYL KETONE). VP: 2.1 @ 68F.
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 10%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM

Ingred Name:2-BUTANONE;(METHYL ETHYL KETONE) (MEK) (SARA 313) (CERCLA).
    VP: 70.0 @ 68F.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 3%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:IRON (III) OXIDE; (IRON OXIDE YELLOW)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: <5.0%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)

Ingred Name:VOLATILE ORGANIC CONTENT(COATING & MATERIAL): 2.81 LB/GL
    (337 G/L)
RTECS #:9999999VO
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:OTHER EYE PROT:SHOWER WHICH MEET ANSI DESIGN CRITERIA 
RTECS #:9999999ZZ
Other REC Limits:NONE RECOMMENDED

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SEVERE EYE IRRIT, REDNESS,
    TEARING & BLURRED VISION. CAN CAUSE MODERATE SKIN IRRITATION,
    DEFATTING, DERMATITIS & TINGLING SENSATION. CHRONIC: MAY PRODUCE
    LIVER & KIDNEY DAMAGE, PERSISTANT COUGH ING, BRAIN DAMAGE AND MAY
    EVEN CAUSE DEATH.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:INHAL: HDCH, FATIGUE, WEAK, NAUS, VOMIT, DIZZ,
    STUPER, DROW, DISTURBED VISION, COUGHING & UNCON. SKIN/EYE: PRLNGD
    CONT CAN CAUSE MOD IRRIT, DEFATT & DERM. EYES: CAN CAUSE SEV IRRIT,
    REDNESS, TEARING &	BLURRED VISION. SKIN(ABSORP): MOD IRRIT,
    DEFATT, DERM, DRY SKIN, RASH. INGEST: BRTH SMELLS OF SOLV. IRRIT TO
    (SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
    CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER & KIDNEY DISORDERS.

=======================  First Aid Measures  =======================

First Aid:EYE: FLUSH W/PLENTY OF WATER FOR 15 TO 30 MINUTES. GET
    MEDICAL ATTN. SKIN: WASH EXPOSED AREA W/MILD SOAP & WATER FOR AT
    LEAST 15 MINUTES. REMOVE CONTAMD CLTHG. INHAL: REMOVE TO FRESH AIR.
    IF BRTHG IS  DFCLT, ADMIN OXYGEN. IF BRTHG HAS STOPPED, GIVE ARTF
    RESP. GET MED ATTN. INGEST: DO NOT INDUCE VOMITING. KEEP VICTIM
    WARM & SEEK IMMED MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1.1%
Upper Limits:11.4%
Extinguishing Media:FOAM, ALCOHOL, FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
    PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLOSED. ISOLATE FROM
    HEAT, SPARKS, ELEC EQUIP & OPEN FLAME. CLOSED CNTNRS MAY EXPLODE
    WHEN EXPOSED TO EXTREME HEAT. DURING EMERGENCY(SUPDAT)

==================  Accidental Release Measures  ==================

Spill Release Procedures:FOLLOW INSTRUCTIONS TO PREVENT HEALTH HAZARDS.
    ELIMINATE ALL SOURCES OF IGNITION, ABSORB LIQUIDS IN ABORBANT
    MATERIAL AND PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:CNTNRS MAY BE HAZ WHEN EMPTIED, SINCE
    EMPTIED CNTNR MAY REACT IN PROD RESIDUALS(VAPS, LIQ &/SOLIDS), ALL
    PRECS GIVEN IN MSDS MUST BE OBSERVED.
Other Precautions:OVEREXP HAS APPARENTLY BEEN FOUND TO CAUSE FOLLOWING
    EFTS IN LAB ANIMALS; LIVER ABNORMS, KIDNEY DMG, LUNG DMG. ALSO
    OVEREXP TO MATL HAS BEEN SUGGESTED AS CAUSE OF FOLLOWING EFTS IN
    HUMANS: CARD ABNORM S, LIVER ABNORMS, KIDNEY DMG & LUNG DMG.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF TLV OF THE PRODUCT OR ANY COMPONENT IS
    EXCEEDED A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED RESP IS ADVISED
    IN ABSENCE OF ENVIRONMENTAL CONTROL. OSHA REGS ALSO PERMIT OTHER
    NIOSH/MSHA RESPS UNDER SP ECIFIED CNDTNS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL(GENL &/LOCAL EXHAUST) VENT TO
    MAINTAIN EXPOSURE BELOW THE TLV'S.
Protective Gloves:PVA COATED/POLYETHYLENE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS(SUPDAT)
Other Protective Equipment:RPTD/PRLNGD SKIN CONT W/GB PROT HANDCREAM,
    WEAR IMPERVIOUS CLTHG & CHEM RESIST BOOTS.	EMER EYEWASH AND DELUGE
    (ING 6)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING THE REST
    ROOM, SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXPLO HAZ:CNDTNS, OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY
    NOT BE IMMED APPARENT, OBTAIN MED ATTN. EFTS OF OVEREXP:LIPS &
    MOUTH, GI IRRIT, NAUS, DIARR, DROW, LOSS OF CON. STATE OF SHOCK, 
    WEAK & RAPID PULSE, COLD-PALE COMPLEXION. EYE PROT:W/FULL LENGTH
    FCSHLD.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:>175F,>79C
Vapor Density:HVR/AIR
Spec Gravity:1.6 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NON SOLUBLE
Appearance and Odor:SOLVENT ODOR.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES.
Hazardous Decomposition Products:HAZARDOUS DECOMPOSITION MAY PRODUCE
    CARBON DIOXIDE &/CARBON MONOXIDE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:RECYCLE LIQUIDS IF POSSIBLE, INCINERATE SOLIDS
    IN ACCORDANCE WITH APPLICABLE REGULATIONS. AS A LAST RESORT
    NEUTRALIZE AND LANDFILL IN ACCORDANCE WITH LOCAL, STATE & FEDERAL
    REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.